How to replace the fuel filler hose on Chevrolet S10?

The first step to replace the Fuel Filler Hose starts with disconnecting the negative Battery Cable while removing the fuel filler cap. The procedure starts by unscrewing the fuel filler pipe attachers which holds the fill pipe housing before lifting the vehicle. An approved gasoline drain container should rest underneath the fuel filler pipe while you disconnect the filler pipe ground strap. Begin by wiping down the vent hose connection and moving the vent hose clamp until loose before cleaning the Fuel Filler Hose connection and subsequently loose its clamp. Initial contamination prevention requires you to detach the Fuel Filler Hose and vent hose followed by capping them off. To install the fuel filler pipe, users need to remove protective caps from the Fuel Filler Hose and vent hose after which they should assemble the filler pipe to the fuel tank fill and vent hoses and the fill pipe housing while maintaining correct alignment with the filler pipe housing. Toe tighten the fill hose clamp to 2.5 n.m (22 lb in) without threading over its specified limit. Tighten the filler pipe ground strap bolt to 15 n.m (11 lb ft) while attaching a washer on the frame's surface. Install the fuel filler pipe to fill pipe housing using attaching screws before tightening them to 1.9 n.m (17 lb in). Afterward install the fuel filler cap while reestablishing the negative Battery Cable connection and check for any sign of leakage.

How to Properly Service and Replace the Fuel Filler Hose on Chevrolet Colorado?

Replacing the Fuel Filler Hose begins with draining part of the Fuel Tank so that its level matches or descends below the fuel fill tube position. After safely elevating your vehicle you can reach the Fuel Filler Hose through the wheelhouse liner thus allowing you to take out the left pickup box wheelhouse liner. The procedure starts with unbolting the Fuel Filler Hose ground strap from the frame before removing the Fuel Filler Hose from the Fuel Tank. The first step for Fuel Filler Hose installation is toconduct the following sequence: disconnect the evap hose from the filler vent tube, remove the Fuel Filler Hose screws before pulling the hose out of the vehicle. The Fuel Tank requires an end cap to be installed. The first step is to remove the Fuel Tank cover before you place the Fuel Filler Hose against the fender. After that, install the Fuel Filler Hose screws while tightening them to 2 n.m (18 lb in). Fit the Fuel Filler Hose onto the Fuel Tank after securing its clamp at 2.5 n.m (22 lb in). Thread the evap hose to the filler vent tube while using the bolt for securing the Fuel Filler Hose ground strap to the frame. Secure the bolt at 9 n.m (80 lb in). Below this step are two tasks: first reinstall the left pickup box wheelhouse liner and lower the vehicle and then refill the Fuel Tank followed by installing the fuel fill cap while performing leak inspections on the system.

OEM Chevrolet Fuel Filler Hose

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

449 Fuel Filler Hoses found

View related parts
Chevrolet Upper Hose Part Number: 15124940
$50.50 MSRP: $97.15
You Save: $46.65 (49%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose, Fuel Tank Filler; Fuel Hose; Hose
- Position: Upper
- Replaces: 15088336
Fits the following Chevrolet Models:
- Avalanche | 2009-2013 | Black Diamond LS, Black Diamond LT, Black Diamond LTZ, LS, LT, LTZ | 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
- Avalanche 1500 | 2004-2006 | Base, LS, LT, Z66, Z71 | 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS
- Avalanche 2500 | 2004-2006 | Base, LS, LT | 8 Cyl 8.1 L GAS
- Suburban 1500 | 2008-2014 | LS, LT, LTZ | 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
- Tahoe | 2007-2014 | Hybrid, LS, LT, LTZ, PPV, SSV | 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L FULL HYBRID EV-FLEX (FHEV), 8 Cyl 6.0 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 6.2 L FLEX, 8 Cyl 6.2 L GAS
View More
View related parts
Chevrolet Filler Neck Part Number: 22732538
$40.18 MSRP: $62.88
You Save: $22.70 (37%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose, Fuel Tank Filler; Fuel Tank Filler Neck; Fuel Filler Hose; Filler Pipe; Lower Hose
Fits the following Chevrolet Models:
- Equinox | 2005-2009 | LS, LT, LTZ, Sport | 6 Cyl 3.4 L GAS, 6 Cyl 3.6 L GAS
View related parts
Chevrolet Lower Hose Part Number: 22951233
$51.99 MSRP: $81.37
You Save: $29.38 (37%)
ADD TO CART
Product Specifications
- Other Name: Hose Assembly-Fuel Tank Vent
- Position: Lower
- Replaces: 25889326
Fits the following Chevrolet Models:
- Suburban 2500 | 2007-2013 | LS, LT, LTZ | 8 Cyl 6.0 L FLEX, 8 Cyl 6.0 L GAS
View related parts
Chevrolet Connector Hose Part Number: 10356547
$56.17 MSRP: $87.90
You Save: $31.73 (37%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose, Fuel Tank Filler; Fuel Filler Hose; Filler Hose
Fits the following Chevrolet Models:
- Trailblazer | 2005-2009 | Base, LS, LT, SS | 6 Cyl 4.2 L GAS, 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
- Trailblazer EXT | 2005-2006 | LS, LT | 6 Cyl 4.2 L GAS, 8 Cyl 5.3 L GAS
View related parts
Chevrolet Filler Neck Part Number: 96985960
$168.34 MSRP: $251.63
You Save: $83.29 (34%)
ADD TO CART
Product Specifications
- Other Name: Pipe, Fuel Tank Filler; Fuel Tank Filler Neck; Fuel Filler Hose; Filler Pipe
- Replaces: 96653843
Fits the following Chevrolet Models:
- Aveo | 2007-2008 | LS, LT | 4 Cyl 1.6 L GAS
View related parts
Chevrolet Filler Pipe Part Number: 15938962
$172.80 MSRP: $258.29
You Save: $85.49 (34%)
ADD TO CART
Product Specifications
- Other Name: Pipe Assembly-Fuel Tank Filler; Pipe, Fuel Tank Filler
- Replaces: 15113984, 15225008, 15130079, 15289908, 15776491
Fits the following Chevrolet Models:
- Silverado 2500 HD | 2004 | Base, LS, LT, WT | 8 Cyl 6.6 L DIESEL
- Silverado 3500 | 2004 | Base, LS, LT, WT | 8 Cyl 6.6 L DIESEL
View related parts
Chevrolet Filler Pipe Part Number: 19299053
$179.77 MSRP: $268.71
You Save: $88.94 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Pipe, Fuel Tank Filler
- Replaces: 25755765
Fits the following Chevrolet Models:
- Express 1500 | 2003-2004 | Base, LS | 6 Cyl 4.3 L GAS, 8 Cyl 5.3 L GAS
- Express 2500 | 2003-2004 | Base, LS | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L CNG, 8 Cyl 6.0 L GAS
- Express 3500 | 2003-2004 | Base, LS | 8 Cyl 4.8 L GAS, 8 Cyl 6.0 L CNG, 8 Cyl 6.0 L GAS
View More
View related parts
Chevrolet Filler Neck Part Number: 84696025
$207.66 MSRP: $310.40
You Save: $102.74 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Pipe Assembly-Fuel Tank Filler (W/Filler Hose); Fuel Tank Filler Neck; Fuel Filler Hose; Filler Pipe; Pipe, Fuel Tank Filler
- Replaces: 84090500, 84224654, 84392894, 84315254
Fits the following Chevrolet Models:
- Tahoe | 2017-2020 | LS, LT, PPV, Premier, SSV | 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L FLEX, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Filler Neck Part Number: 23395442
$255.81 MSRP: $382.40
You Save: $126.59 (34%)
ADD TO CART
Product Specifications
- Other Name: Pipe Assembly-Fuel Tank Filler; Fuel Tank Filler Neck; Fuel Filler Hose; Filler Pipe; Pipe, Fuel Tank Filler
- Replaces: 22821387
Fits the following Chevrolet Models:
- Silverado 1500 | 2014-2016 | Custom, High Country, LS, LT, LTZ, SSV, WT | 6 Cyl 4.3 L FLEX, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.3 L MILD HYBRID EV-GAS (MHEV), 8 Cyl 6.2 L GAS
View related parts
Chevrolet Filler Neck Part Number: 22951209
$260.63 MSRP: $389.57
You Save: $128.94 (34%)
ADD TO CART
Product Specifications
- Other Name: Pipe Assembly-Fuel Tank Filler; Fuel Tank Filler Neck; Fuel Filler Hose; Filler Pipe; Filler Hose; Pipe, Fuel Tank Filler
- Replaces: 20962111, 20918330, 25836089
Fits the following Chevrolet Models:
- Silverado 1500 | 2007-2013 | Hybrid, LS, LT, LTZ, WT, XFE | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L FLEX, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L FULL HYBRID EV-FLEX (FHEV), 8 Cyl 6.0 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 6.0 L GAS, 8 Cyl 6.2 L FLEX
- Silverado 2500 HD | 2007-2012 | LT, LTZ, WT | 8 Cyl 6.0 L FLEX, 8 Cyl 6.0 L GAS
- Silverado 3500 HD | 2007-2012 | LT, LTZ, WT | 8 Cyl 6.0 L FLEX, 8 Cyl 6.0 L GAS
View More
View related parts
Chevrolet Filler Pipe Part Number: 20979211
$352.35 MSRP: $526.69
You Save: $174.34 (34%)
ADD TO CART
Product Specifications
- Other Name: Pipe Assembly-Fuel Tank Filler; Pipe, Fuel Tank Filler
- Replaces: 15117948, 15846495, 25957106, 20934914, 20829348, 25849098, 25849110, 25957107
Fits the following Chevrolet Models:
- Express 1500 | 2007-2014 | Base, LS, LT | 6 Cyl 4.3 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS
- Express 2500 | 2007-2020 | Base, LS, LT | 6 Cyl 4.3 L FLEX, 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L FLEX, 8 Cyl 4.8 L GAS, 8 Cyl 6.0 L CNG, 8 Cyl 6.0 L FLEX, 8 Cyl 6.0 L GAS
- Express 3500 | 2007-2020 | Base, LS, LT | 6 Cyl 4.3 L FLEX, 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L FLEX, 8 Cyl 4.8 L GAS, 8 Cyl 6.0 L CNG, 8 Cyl 6.0 L FLEX, 8 Cyl 6.0 L GAS
View More
View related parts
Chevrolet Filler Neck Part Number: 15648274
$23.17 MSRP: $34.48
You Save: $11.31 (33%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Pipe Assembly-Fuel Tank Filler; Fuel Filler Hose; Pipe, Fuel Tank Filler
Fits the following Chevrolet Models:
- S10 | 1994-1995 | Base, LS, SS, ZR2 | 4 Cyl 2.2 L GAS, 6 Cyl 4.3 L GAS
View related parts
Chevrolet Lower Hose Part Number: 25887138
$66.27 MSRP: $98.61
You Save: $32.34 (33%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose, Fuel Tank Filler
- Position: Lower
- Replaces: 15784037
Fits the following Chevrolet Models:
- Cobalt | 2005-2008 | Base, LS, LT, LTZ, SS, Sport | 4 Cyl 2.0 L GAS, 4 Cyl 2.2 L GAS, 4 Cyl 2.4 L GAS
View related parts
Chevrolet Filler Neck Part Number: 20792232
$86.14 MSRP: $128.18
You Save: $42.04 (33%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Pipe Assembly-Fuel Tank Filler; Fuel Tank Filler Neck; Fuel Filler Hose; Filler Pipe; Pipe, Fuel Tank Filler
- Replaces: 25858609
Fits the following Chevrolet Models:
- Tahoe | 2008-2009 | Hybrid | 8 Cyl 6.0 L FULL HYBRID EV-GAS (FHEV)
View related parts
Chevrolet Filler Hose Part Number: 84533160
$56.54 MSRP: $77.32
You Save: $20.78 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose, Fuel Tank Filler; Fuel Filler Hose
- Replaces: 23375744, 84240992
Fits the following Chevrolet Models:
- Silverado 1500 | 2017-2018 | LS, LT, WT | 6 Cyl 4.3 L FLEX, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS
View related parts
Chevrolet Upper Hose Part Number: 15023466
$55.26 MSRP: $64.68
You Save: $9.42 (15%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose, Fuel Tank Filler; Fuel Hose; Lower Hose; Hose
- Position: Upper
Fits the following Chevrolet Models:
- Blazer | 1995-2000 | Base, LS, LT, Trailblazer | 6 Cyl 4.3 L GAS
- S10 | 1995-2000 | Base, LS, SS, Xtreme, ZR2 | 4 Cyl 2.2 L FLEX, 4 Cyl 2.2 L GAS, 6 Cyl 4.3 L GAS
View related parts
Chevrolet Filler Hose Part Number: 15842789
Product Specifications
- Other Name: Hose, Fuel Tank Filler; Fuel Filler Hose
Fits the following Chevrolet Models:
- Traverse | 2009-2017 | LS, LT, LTZ, Premier | 6 Cyl 3.6 L GAS
View related parts
Chevrolet Filler Neck Part Number: 15198428
Product Specifications
- Other Name: Pipe Assembly-Fuel Tank Filler; Fuel Tank Filler Neck; Fuel Filler Hose; Filler Pipe; Pipe, Fuel Tank Filler
Fits the following Chevrolet Models:
- Silverado 1500 | 1999-2004 | Base, Hybrid, LS, LT, SS, WT, Z71 Off-Road | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
- Silverado 1500 HD | 2001-2003 | LS, LT | 8 Cyl 6.0 L GAS
- Silverado 2500 | 1999-2004 | Base, LS, LT, WT | 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L BI-FUEL, 8 Cyl 6.0 L CNG, 8 Cyl 6.0 L GAS
- Silverado 2500 HD | 2001-2004 | Base, LS, LT, WT | 8 Cyl 6.0 L BI-FUEL, 8 Cyl 6.0 L CNG, 8 Cyl 6.0 L GAS, 8 Cyl 6.6 L DIESEL, 8 Cyl 8.1 L GAS
- Silverado 3500 | 2001-2004 | Base, LS, LT, WT | 8 Cyl 6.0 L CNG, 8 Cyl 6.0 L GAS, 8 Cyl 6.6 L DIESEL, 8 Cyl 8.1 L GAS
View More
View related parts
Chevrolet Filler Hose Part Number: 25802833
$17.48 MSRP: $26.01
You Save: $8.53 (33%)
Product Specifications
- Other Name: Hose, Fuel Tank Filler; Fuel Filler Hose
Fits the following Chevrolet Models:
- Equinox | 2010-2011 | LS, LT, LTZ | 4 Cyl 2.4 L GAS, 6 Cyl 3.0 L FLEX, 6 Cyl 3.0 L GAS
View related parts
Chevrolet Filler Hose Part Number: 22951224
$24.54 MSRP: $36.52
You Save: $11.98 (33%)
Product Specifications
- Other Name: Hose, Fuel Tank Filler; Fuel Filler Hose
- Replaces: 15944407
Fits the following Chevrolet Models:
- Silverado 1500 | 2014-2016, 2007-2012 | Hybrid, LS, LT, LTZ, WT, XFE | 6 Cyl 4.3 L FLEX, 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L FLEX, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.3 L MILD HYBRID EV-GAS (MHEV), 8 Cyl 6.0 L FULL HYBRID EV-FLEX (FHEV), 8 Cyl 6.0 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 6.0 L GAS, 8 Cyl 6.2 L FLEX
- Silverado 2500 HD | 2007-2012 | LT, LTZ, WT | 8 Cyl 6.0 L FLEX, 8 Cyl 6.0 L GAS
- Silverado 3500 HD | 2007-2012 | LT, LTZ, WT | 8 Cyl 6.0 L FLEX, 8 Cyl 6.0 L GAS
View More

| Page 1 of 23 |Next >

1-20 of 449 Results

Chevrolet Fuel Filler Hose

Choose OEM Fuel Filler Hose, you're making the optimal decision for superior quality and perfect performance. You can feel confident because each component goes through stringent quality checks. Every part is carefully built to comply with Chevrolet's factory specifications. You'll enjoy a smooth, worry-free installation that fits just right. At ChevyPartsDeal.com, you'll find it easy to get top-quality OEM Chevrolet Fuel Filler Hose. You can shop at highly competitive prices and protect your budget. All our genuine Chevrolet parts include a dependable manufacturer's warranty. You'll also appreciate our straightforward return policy and swift delivery services for extra convenience.

Chevrolet Fuel Filler Hose allows gas to travel smoothly through the pump nozzle to the tank and prevent leakages. With compacts, SUVs, and trucks accessible to everyday drivers and first-time buyers since 1911, Chevrolet has pursued every possible form of practicality and punch, stuffing roadworthy toughness into its compact packages without the need to sell a kidney. Chevy translates to simple cabins, easy-to-use buttons, engines that do not whine when pressed, and unbelievable mileage figures that allow weekend voyages to go past the next gas station. Aggressive styling is never obtrusive to the point it takes over functionality and therefore a city runabout or a cross-country hauler can fit in tight parking spaces and loading areas. The constant improvements include accommodating the frame, smarter driver assistance, and quieter cabins, which are only a few of the things that Chevy rolls out with each model year since it sees progress more like standard maintenance than a marketing spectacle. The outcome that the owners can observe is cold start, highway merge, and prolonged ownership period when the value remains civil. The Fuel Filler Hose is the highly important in the hardware which makes them painless. The Fuel Filler Hose of the new systems is made with strata of rubber and molded bends to cope with the shapes of the body, keep vibration off, ethanol-resistant corrosion, and snaps tight to ensure the vapour remains indoors where it belongs as you fill up during the scorching sun or snowy weather. A damaged Fuel Filler Hose can be taken out in two screw turns and changed out in minutes, leaving Chevy tanks unopened and secure without any special equipment. The drivers of Chevrolet enjoy spill-free filling, constant mpgs, and trust that it will be fine each time the pump clicks.

Chevrolet Fuel Filler Hose Parts and Q&A

Hose
15748509
Q: How to replace the fuel filler hose on Chevrolet S10?
A:
The first step to replace the Fuel Filler Hose starts with disconnecting the negative Battery Cable while removing the fuel filler cap. The procedure starts by unscrewing the fuel filler pipe attachers which holds the fill pipe housing before lifting the vehicle. An approved gasoline drain container should rest underneath the fuel filler pipe while you disconnect the filler pipe ground strap. Begin by wiping down the vent hose connection and moving the vent hose clamp until loose before cleaning the Fuel Filler Hose connection and subsequently loose its clamp. Initial contamination prevention requires you to detach the Fuel Filler Hose and vent hose followed by capping them off. To install the fuel filler pipe, users need to remove protective caps from the Fuel Filler Hose and vent hose after which they should assemble the filler pipe to the fuel tank fill and vent hoses and the fill pipe housing while maintaining correct alignment with the filler pipe housing. Toe tighten the fill hose clamp to 2.5 n.m (22 lb in) without threading over its specified limit. Tighten the filler pipe ground strap bolt to 15 n.m (11 lb ft) while attaching a washer on the frame's surface. Install the fuel filler pipe to fill pipe housing using attaching screws before tightening them to 1.9 n.m (17 lb in). Afterward install the fuel filler cap while reestablishing the negative Battery Cable connection and check for any sign of leakage.
Filler Neck
25797163
Q: How to Properly Service and Replace the Fuel Filler Hose on Chevrolet Colorado?
A:
Replacing the Fuel Filler Hose begins with draining part of the Fuel Tank so that its level matches or descends below the fuel fill tube position. After safely elevating your vehicle you can reach the Fuel Filler Hose through the wheelhouse liner thus allowing you to take out the left pickup box wheelhouse liner. The procedure starts with unbolting the Fuel Filler Hose ground strap from the frame before removing the Fuel Filler Hose from the Fuel Tank. The first step for Fuel Filler Hose installation is toconduct the following sequence: disconnect the evap hose from the filler vent tube, remove the Fuel Filler Hose screws before pulling the hose out of the vehicle. The Fuel Tank requires an end cap to be installed. The first step is to remove the Fuel Tank cover before you place the Fuel Filler Hose against the fender. After that, install the Fuel Filler Hose screws while tightening them to 2 n.m (18 lb in). Fit the Fuel Filler Hose onto the Fuel Tank after securing its clamp at 2.5 n.m (22 lb in). Thread the evap hose to the filler vent tube while using the bolt for securing the Fuel Filler Hose ground strap to the frame. Secure the bolt at 9 n.m (80 lb in). Below this step are two tasks: first reinstall the left pickup box wheelhouse liner and lower the vehicle and then refill the Fuel Tank followed by installing the fuel fill cap while performing leak inspections on the system.