How do electrically operated concealed headlights function and what are the manual opening methods in emergencies on Pontiac Firebird?

The electrically operated concealed headlights utilize a permanent magnet/actuator motor connector linked to an assembly that raises and lowers the headlights. When activated from the dashboard switch, relays control the motors, which turn off upon reaching the full open position and are reactivated to close the assemblies when the switch is turned off. In emergencies, manual opening methods vary based on the headlight door motor model. For motors with a single-hole knob, a ballpoint pen or similar object can be inserted into the hole and turned clockwise until a click is heard, allowing for manual closure by reversing the action, ensuring no voltage is present at the motor terminals by disconnecting the electrical connections at the isolation relay on the right side of the vehicle's radiator cradle. For motors with a knurled knob featuring two holes, the headlights should be turned on, and the hood opened; turning the knob clockwise until the assembly is fully open will require increased effort and may produce a click when the limit is reached. To close the assembly manually, the headlights must be turned off, and the knob should be rotated counter-clockwise.

How should headlights be aimed correctly to avoid blinding oncoming drivers and ensure optimal visibility on the road on Pontiac G6?

The headlights should be aligned properly to prevent directing light at other motorists and to ensure good visibility on the road, with the headlight aiming advised every twelve months and after a change of headlights, or front-end bodywork. There are no vertical adjustment screws but there are horizontal adjustment screws which are situated at the back of each housing of the headlights. There is available a basic technique, which only requires masking tape, a bare wall, and a flat surface. Tape a few lines horizontally; tape one set of line vertically parallel to the centerline of the car as well as both headlights; it is better if the vehicle is quite close to the wall, perhaps no more than 2-3 inches. All measurements should be conducted with the motor vehicle parked 25 feet away from the wall, in a level ground, it should have a half-full tank gas and should not be transporting any heavy load. In the case of low beam adjustment then the high-intensity dwell should be situated two inches below a straight horizontal line For live adjustment the screw which is then made to move up and down should be turned clockwise to raise the beam up then anti-clockwise to lower the beam down. When using the high beam the high-intensity zone should be slightly below a horizontal line. There is unintentional data misalignment which may make it impossible to align high and low beam, prioritize low beams for safety. Last, have the headlights aligned by an expert as soon as one can, at one's earliest convenience.

OEM Pontiac Headlight

Headlamp

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

133 Headlights found

View related parts
Pontiac Headlamp Assembly, Passenger Side Part Number: 25851403
$168.31 MSRP: $251.63
You Save: $83.32 (34%)
ADD TO CART
Product Specifications
- Other Name: Headlight Assembly; Head Lamps; Headlight; Composite Headlamp; Headlamp, Capsule/Headlamp/Fog Lamp
- Position: Passenger Side
- Replaces: 10372371, 21998963, 10347164, 10438690
Fits the following Pontiac Models:
- Grand Prix | 2004-2008 | Base, GT, GT1, GT2, GTP, GXP | 6 Cyl 3.8 L GAS, 8 Cyl 5.3 L GAS
View related parts
Pontiac Headlamp Assembly Part Number: 25949657
$104.83 MSRP: $150.00
You Save: $45.17 (31%)
ADD TO CART
Product Specifications
- Other Name: Capsule Assembly-Headlamp; Headlight Assembly; Other Lamp; Headlight; Sealed Beam; Lamp Assembly; Headlamp Capsule; Capsule; Headlamp
- Replaces: 05968097, 05972850, 5972850, 16522983, 5968097, 25796739
Fits the following Pontiac Models:
- Fiero | 1984-1988 | Base, GT, SE, Sport, Value Leader | 2.5L L4, 2.8L V6, 4 Cyl 2.5 L GAS, 6 Cyl 2.8 L GAS
- Firebird | 1982-1990 | Base, Formula, S/E, Trans Am, Trans Am GTA, Trans Am GTA SE | 2.5L L4, 2.8L V6, 3.1L V6, 3.8L V6, 4 Cyl 2.5 L GAS, 5.0L V8, 5.7L V8, 6 Cyl 2.8 L GAS, 6 Cyl 3.8 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.7 L GAS
- Phoenix | 1982-1984 | Base, LE, SE | 2.5L L4, 2.8L V6, 4 Cyl 2.5 L GAS, 6 Cyl 2.8 L GAS
- T1000 | 1982-1987 | Base | 1.6L L4, 4 Cyl 1.6 L GAS
View More
View related parts
Pontiac Headlamp Assembly, Driver Side Part Number: 16503161
$109.69 MSRP: $145.28
You Save: $35.59 (25%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Capsule, Capsule/Headlamp/Fog Lamp; Headlight; Composite Assembly; Headlamp
- Position: Driver Side
Fits the following Pontiac Models:
- Firebird | 1998-2002 | Base, Formula, Trans Am | 6 Cyl 3.8 L GAS, 8 Cyl 5.7 L GAS
- J2000 Sunbird | 1985 | Base, LE, SE | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L GAS
- Sunbird | 1986-1994 | Base, GT, LE, LE Value Leader, SE, Value Leader | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L GAS, 6 Cyl 3.1 L GAS
View More
View related parts
Pontiac Headlamp Assembly, Driver Side Part Number: 16503162
$77.60 MSRP: $150.23
You Save: $72.63 (49%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Capsule, Capsule/Headlamp/Fog Lamp; Headlight; Composite Assembly; Headlamp
- Position: Driver Side
Fits the following Pontiac Models:
- Firebird | 1998-2002 | Base, Formula, Trans Am | 6 Cyl 3.8 L GAS, 8 Cyl 5.7 L GAS
- J2000 Sunbird | 1985 | Base, LE, SE | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L GAS
- Sunbird | 1986-1994 | Base, GT, LE, LE Value Leader, SE, Value Leader | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L GAS, 6 Cyl 3.1 L GAS
View More
View related parts
Pontiac Lens & Housing, Driver Side Part Number: 19149589
$135.31 MSRP: $181.10
You Save: $45.79 (26%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Capsule Assembly, Headlamp; Capsule, Capsule/Headlamp/Fog Lamp
- Position: Driver Side
- Replaces: 16522599
Fits the following Pontiac Models:
- Grand Prix | 1997-2003 | GT, GTP, SE | 6 Cyl 3.1 L GAS, 6 Cyl 3.8 L GAS
View related parts
Pontiac Headlamp Assembly, Driver Side Part Number: 22713668
$343.52 MSRP: $513.59
You Save: $170.07 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlight; Composite Assembly; Headlamp, Capsule/Headlamp/Fog Lamp
- Position: Driver Side
- Replaces: 22708376
Fits the following Pontiac Models:
- Sunfire | 2003-2005 | Base, GT, SE | 4 Cyl 2.2 L GAS
View related parts
Pontiac Lens & Housing, Driver Side Part Number: 16530509
$92.01 MSRP: $136.94
You Save: $44.93 (33%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Capsule Assembly, Headlamp (W/O Bracket-Left-Hand); Capsule, Capsule/Headlamp/Fog Lamp; Housing, Capsule/Headlamp/Fog Lamp
- Position: Driver Side
Fits the following Pontiac Models:
- Montana | 1999-2005 | Base | 6 Cyl 3.4 L GAS
- Trans Sport | 1997-1998 | Base, Montana | 6 Cyl 3.4 L GAS
View related parts
Pontiac Lens & Housing, Passenger Side Part Number: 16530510
$92.01 MSRP: $136.94
You Save: $44.93 (33%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Capsule, Capsule/Headlamp/Fog Lamp; Housing, Capsule/Headlamp/Fog Lamp
- Position: Passenger Side
Fits the following Pontiac Models:
- Montana | 1999-2005 | Base | 6 Cyl 3.4 L GAS
- Trans Sport | 1997-1998 | Base, Montana | 6 Cyl 3.4 L GAS
View related parts
Pontiac Headlamp Assembly Part Number: 88975714
$191.82 MSRP: $286.79
You Save: $94.97 (34%)
Product Specifications
- Other Name: Headlamp; Headlight; Composite Assembly; Headlamp, Capsule/Headlamp/Fog Lamp
Fits the following Pontiac Models:
- Vibe | 2009-2010 | AWD, Base, GT | 4 Cyl 1.8 L GAS, 4 Cyl 2.4 L GAS
View related parts
Pontiac Headlamp Assembly, Driver Side Part Number: 10305768
$271.20 MSRP: $405.46
You Save: $134.26 (34%)
Product Specifications
- Other Name: Capsule Assembly-Headlamp; Headlight; Composite Assembly; Capsule, Capsule/Headlamp/Fog Lamp
- Position: Driver Side
- Replaces: 10304889, 10411586
Fits the following Pontiac Models:
- Aztek | 2001-2005 | Base, GT, Rally | 6 Cyl 3.4 L GAS
View related parts
Pontiac Sealed Beam Part Number: 16502973
Product Specifications
- Other Name: Bulb, Headlamp; Headlamp; Headlamp, Capsule/Headlamp/Fog Lamp; Bulb, Capsule/Headlamp/Fog Lamp
- Replaces: 16512621
Fits the following Pontiac Models:
- Firebird | 1991-1997 | Base, Formula, Trans Am, Trans Am GT, Trans Am GTA | 6 Cyl 3.4 L GAS, 6 Cyl 3.8 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.7 L GAS
View related parts
Pontiac Headlamp Assembly Part Number: 16510744
Product Specifications
- Other Name: Capsule Assembly-Headlamp; Headlight; Composite Headlamp; Composite Assembly; Headlamp; Capsule, Capsule/Headlamp/Fog Lamp
Fits the following Pontiac Models:
- Grand Prix | 1991-1996 | Base, GT, GTP, LE, SE, STE | 4 Cyl 2.3 L GAS, 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS
View related parts
Pontiac Headlamp Assembly, Passenger Side Part Number: 16503171
Product Specifications
- Other Name: Capsule, Capsule/Headlamp/Fog Lamp; Headlight; Composite Assembly; Headlamp
- Position: Passenger Side
Fits the following Pontiac Models:
- Firebird | 1998-2002 | Base, Formula, Trans Am | 6 Cyl 3.8 L GAS, 8 Cyl 5.7 L GAS
- J2000 Sunbird | 1985 | Base, LE, SE | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L GAS
- Sunbird | 1986-1994 | Base, GT, LE, LE Value Leader, SE, Value Leader | 4 Cyl 1.8 L GAS, 4 Cyl 2.0 L GAS, 6 Cyl 3.1 L GAS
View More
View related parts
Pontiac Headlamp Assembly, Black Bezel, Passenger Side Part Number: 25973531
$91.47 MSRP: $136.14
You Save: $44.67 (33%)
Product Specifications
- Other Name: Headlight; Headlamp, Capsule/Headlamp/Fog Lamp
- Position: Passenger Side
Fits the following Pontiac Models:
- Solstice | 2009 | Base, GXP | 4 Cyl 2.0 L GAS, 4 Cyl 2.4 L GAS
View related parts
Pontiac Headlamp Assembly, Driver Side Part Number: 19149891
Product Specifications
- Other Name: Headlight Assembly; Head Lamps; Headlight; Composite Headlamp; Headlamp, Capsule/Headlamp/Fog Lamp
- Position: Driver Side
- Replaces: 16530417, 16526203, 16526111
Fits the following Pontiac Models:
- Grand Prix | 1997-2003 | GT, GTP, SE | 6 Cyl 3.1 L GAS, 6 Cyl 3.8 L GAS
View related parts
Pontiac Headlamp Assembly, Passenger Side Part Number: 19149893
Product Specifications
- Other Name: Headlight Assembly; Head Lamps; Headlight; Composite Headlamp; Headlamp, Capsule/Headlamp/Fog Lamp
- Position: Passenger Side
- Replaces: 16530418, 16525774, 16525026, 16526112, 16526204
Fits the following Pontiac Models:
- Grand Prix | 1997-2003 | GT, GTP, SE | 6 Cyl 3.1 L GAS, 6 Cyl 3.8 L GAS
View related parts
Pontiac Headlamp Assembly, Passenger Side Part Number: 16521462
Product Specifications
- Other Name: Headlight; Composite Assembly; Headlamp, Capsule/Headlamp/Fog Lamp
- Position: Passenger Side
Fits the following Pontiac Models:
- Grand Prix | 1990-1996 | Base, GT, GTP, LE, SE, STE | 4 Cyl 2.3 L GAS, 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS
View related parts
Pontiac Headlamp Assembly Part Number: 16510743
Product Specifications
- Other Name: Headlight; Composite Headlamp; Composite Assembly; Headlamp; Capsule, Capsule/Headlamp/Fog Lamp
Fits the following Pontiac Models:
- Grand Prix | 1991-1996 | Base, GT, GTP, LE, SE, STE | 4 Cyl 2.3 L GAS, 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS
View related parts
Pontiac Composite Headlamp Part Number: 19245096
Product Specifications
- Other Name: Headlamp, Turn Signal & Cornering & Daytime Running; Headlight; Headlamp, Turn Signal & Cornering; Chassis/Body Marker/Hazard; Capsule/Fog Lamp
- Position: Front
- Replaces: 25770737, 10368523, 15220037
Fits the following Pontiac Models:
- Bonneville | 2005 | GXP, SE, SLE | 6 Cyl 3.8 L GAS, 8 Cyl 4.6 L GAS
View related parts
Pontiac Headlamp Assembly, Driver Side Part Number: 19245097
Product Specifications
- Other Name: Headlamp, Turn Signal & Cornering & Daytime Running; Headlight; Composite Headlamp; Turn Signal, Cornering, Daytime Running; Chassis/Body Marker, Hazard, Fog Lamp.
- Position: Driver Side
- Replaces: 25762531, 15220039
Fits the following Pontiac Models:
- Bonneville | 2004-2005 | GXP | 8 Cyl 4.6 L GAS

| Page 1 of 7 |Next >

1-20 of 133 Results

Pontiac Headlight

Choose OEM Headlight, you're making the optimal decision for superior quality and perfect performance. You can feel confident because each component goes through stringent quality checks. Every part is carefully built to comply with Pontiac's factory specifications. You'll enjoy a smooth, worry-free installation that fits just right. At ChevyPartsDeal.com, you'll find it easy to get top-quality OEM Pontiac Headlight. You can shop at highly competitive prices and protect your budget. All our genuine Pontiac parts include a dependable manufacturer's warranty. You'll also appreciate our straightforward return policy and swift delivery services for extra convenience.

Pontiac Headlight is a high power, long lasting light which provides the driver with a safer light after the sun rays. Pontiac made its name on broad streets, sudden acceleration and a promise that all steering response would be direct giving young drivers the feel of the real road and not the dull commuter response. Every decade the badge continued to fiddle with body lines, cab interior design and suspension sounds, and was always trying to find the balance between adrenaline and cost, but at the same time was lively enough to make shopping trips into mini-road trips. Infotainment enhancements, reduced distance between panel gaps, and the use of bold paint colors emphasized the message that everyday practicality could be on the driveway with personality, without emptying wallets of its owners. That anxious soul goes thrumming through each of the models and the badge has become less of a means to travel and more of a suggestion to drive with purpose and with passion, mile after mile in any weather. The construction of the Headlights shifted towards simple sealed beam to an integrated module of composites where the turn signals and the thin parking lamps are integrated and the weight is trimmed and the airflow at the nose is made smooth. They come with Headlight options inside each Pontiac housing: halogen to minimize start-up cost, xenon to cut-off better, and a highly efficient LED that requires less power and yet, with more than 50,000 hours to shine, all sealed by UV lenses that resist the haze and maintain the beam pattern sharp on rainy, foggy or moonless backroad. Pontiac Headlight life implies that there is less changing and more drive time than Headlight bulb changing.

Pontiac Headlight Parts and Q&A

Headlamp Assembly
25949657
Q: How do electrically operated concealed headlights function and what are the manual opening methods in emergencies on Pontiac Firebird?
A:
The electrically operated concealed headlights utilize a permanent magnet/actuator motor connector linked to an assembly that raises and lowers the headlights. When activated from the dashboard switch, relays control the motors, which turn off upon reaching the full open position and are reactivated to close the assemblies when the switch is turned off. In emergencies, manual opening methods vary based on the headlight door motor model. For motors with a single-hole knob, a ballpoint pen or similar object can be inserted into the hole and turned clockwise until a click is heard, allowing for manual closure by reversing the action, ensuring no voltage is present at the motor terminals by disconnecting the electrical connections at the isolation relay on the right side of the vehicle's radiator cradle. For motors with a knurled knob featuring two holes, the headlights should be turned on, and the hood opened; turning the knob clockwise until the assembly is fully open will require increased effort and may produce a click when the limit is reached. To close the assembly manually, the headlights must be turned off, and the knob should be rotated counter-clockwise.
Headlamp Assembly, Passenger Side
20821144
Q: How should headlights be aimed correctly to avoid blinding oncoming drivers and ensure optimal visibility on the road on Pontiac G6?
A:
The headlights should be aligned properly to prevent directing light at other motorists and to ensure good visibility on the road, with the headlight aiming advised every twelve months and after a change of headlights, or front-end bodywork. There are no vertical adjustment screws but there are horizontal adjustment screws which are situated at the back of each housing of the headlights. There is available a basic technique, which only requires masking tape, a bare wall, and a flat surface. Tape a few lines horizontally; tape one set of line vertically parallel to the centerline of the car as well as both headlights; it is better if the vehicle is quite close to the wall, perhaps no more than 2-3 inches. All measurements should be conducted with the motor vehicle parked 25 feet away from the wall, in a level ground, it should have a half-full tank gas and should not be transporting any heavy load. In the case of low beam adjustment then the high-intensity dwell should be situated two inches below a straight horizontal line For live adjustment the screw which is then made to move up and down should be turned clockwise to raise the beam up then anti-clockwise to lower the beam down. When using the high beam the high-intensity zone should be slightly below a horizontal line. There is unintentional data misalignment which may make it impossible to align high and low beam, prioritize low beams for safety. Last, have the headlights aligned by an expert as soon as one can, at one's earliest convenience.