How to replace the rear door hinge on GMC Savana 1500?

The first step to replace a rear Door Hinge requires removing the door from the car. The next step involves erasing the sealer around the hinge before making markings to show the current hinge positions on body pillar or door. Open each centric point on the base of mig weld marks with a pilot drill that extends entirely through the spot welds. Drill a 13 mm (1/2 in) hole through the hinge base along with the body pillar or door by using the smaller hole as a guide. Use a chisel to detach the hinge from the door or body pillar when weld residues exist before removing the hinges. Before installation users must deburr holes within the hinge pillar or door then check the flatness of the hinge seating area. Apply medium-bodied sealer on the mating hinge surface while painting inner and outer hinge pillar and door surfaces at the mounting zone. The service replacement hinges should be installed through the scribe marks after position into the body pillar or door while using the bolts and tapping plate which come with the kit. First tighten bolts to 5 nm (44 lb in) preliminary torque strength. Check the door alignment before bolting it into the body since the door must not close completely until you verify the lock engagement with the striker before tightening it to 25 nm torque (18 lb ft). After sealer application to the hinges users should perform a paint job on the hinge assembly before installing the door onto the vehicle.

How to replace the front side door hinge pin and bushings on GMC Savana 1500?

The first step to replace front side door hinge pins and bushings is extracting the retainer pieces from the hinge pins. Using locking pliers secure the lower hinge pin while delivering it out with a soft-faced hammer. The door needs temporary support through lower hinge installation of a bolt. After acquiring the upper hinge pin with locking pliers you should drive it out with a soft-faced hammer. The bolt should be removed from the lower hinge pin opening and you need help to lift off the door from the vehicle. Remove the upper hinge pin bushings from the door by using an appropriate tool while doing the same with the lower hinge pin bushings from the body. Insert the lower hinge pin bushings through the body using a suitable fitting tool and do the same for the upper hinge pin bushings on the door. Two persons should assist with door refitting to the vehicle and maintain temporary positioning with a lower hinge bolt. Drive the upper hinge pin into the upper hinge through the pointed end using a soft-faced hammer before extracting the temporary bolt from the lower hinge. Then drive the lower hinge pin into the lower hinge from below through the pointed end by using the soft-faced hammer. Affix the hinge pin retainers onto their corresponding hinge pins.

OEM GMC Savana 1500 Door Hinge

Interior Door Hinge

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

18 Door Hinges found

View related parts
GMC Savana 1500 Hinge, Lower Part Number: 19257344
$162.00 MSRP: $253.57
You Save: $91.57 (37%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Intermediate Side Door Lower (Door & Body Side); Door Hinge; Hinge Kit, Door Hinge
- Position: Lower
- Replaced by: 19540842
- Replaces: 15993408, 19210560, 19120835
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Upper Part Number: 19257343
$185.24 MSRP: $279.46
You Save: $94.22 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Intermediate Side Door Upper (Door & Body Side); Door Hinge; Hinge Kit, Door Hinge
- Position: Upper
- Replaced by: 19540841
- Replaces: 15993404, 19120836, 19210561
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge Part Number: 19257342
$165.54 MSRP: $247.50
You Save: $81.96 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Rear Lower
- Replaces: 15993421, 19120834, 19210562
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Rear Upper Part Number: 19257341
$162.60 MSRP: $245.30
You Save: $82.70 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Rear Side Door Upper (Door & Body Side); Door Hinge; Hinge Kit, Door Hinge
- Position: Rear Upper
- Replaced by: 19540839
- Replaces: 19120832, 19210563, 15993415
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Lower Hinge, Passenger Side Part Number: 15994458
$261.31 MSRP: $390.68
You Save: $129.37 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Hinge, Door Hinge; Door Hinge
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Lower Hinge, Driver Side Part Number: 15994457
$261.31 MSRP: $390.68
You Save: $129.37 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Hinge, Door Hinge; Door Hinge
- Position: Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Upper Passenger Side Part Number: 19168524
$82.44 MSRP: $159.91
You Save: $77.47 (49%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Intermediate Side Door Upper (Body Side); Door Hinge
- Position: Upper Passenger Side
- Replaces: 15993424, 15993411, 19120833, 19120837
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2007 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Passenger Side Part Number: 19120098
$131.62 MSRP: $188.34
You Save: $56.72 (31%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Passenger Side
- Replaces: 15993244
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Driver Side Part Number: 19120097
$131.62 MSRP: $188.34
You Save: $56.72 (31%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Driver Side
- Replaces: 15993243
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Upper Hinge, Passenger Side Part Number: 15994452
$187.07 MSRP: $265.40
You Save: $78.33 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Upper Hinge, Driver Side Part Number: 15994451
$187.07 MSRP: $265.40
You Save: $78.33 (30%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge Part Number: 15993424
$82.44 MSRP: $159.91
You Save: $77.47 (49%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Rear Lower
- Replaced by: 19168524
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2007 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Passenger Side Part Number: 15993260
$110.97 MSRP: $158.78
You Save: $47.81 (31%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Driver Side Part Number: 15993259
$142.29 MSRP: $212.73
You Save: $70.44 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Passenger Side Part Number: 15993238
$132.90 MSRP: $198.69
You Save: $65.79 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Driver Side Part Number: 15993237
$132.90 MSRP: $198.69
You Save: $65.79 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Passenger Side Part Number: 15993232
$132.90 MSRP: $198.69
You Save: $65.79 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Driver Side Part Number: 15993231
$132.90 MSRP: $198.69
You Save: $65.79 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS

GMC Savana 1500 Door Hinge

Want to cut long-term maintenance and repair costs? Choose OEM Door Hinge. Those parts deliver top durability you can trust. On our site, you'll find a huge catalog of genuine GMC Savana 1500 parts. Prices are unbeatable, so you can keep more in your pocket. Every OEM GMC Savana 1500 Door Hinge includes a manufacturer's warranty. You can also get an easy return policy that keeps buying risk free. Fast delivery, get your car on the road quickly. It's simple to search, compare, and order. Stop guessing about quality or fit. Order today and save with parts that last.

GMC Savana 1500 Door Hinge Parts and Q&A

Hinge, Upper
19257343
Q: How to replace the rear door hinge on GMC Savana 1500?
A:
The first step to replace a rear Door Hinge requires removing the door from the car. The next step involves erasing the sealer around the hinge before making markings to show the current hinge positions on body pillar or door. Open each centric point on the base of mig weld marks with a pilot drill that extends entirely through the spot welds. Drill a 13 mm (1/2 in) hole through the hinge base along with the body pillar or door by using the smaller hole as a guide. Use a chisel to detach the hinge from the door or body pillar when weld residues exist before removing the hinges. Before installation users must deburr holes within the hinge pillar or door then check the flatness of the hinge seating area. Apply medium-bodied sealer on the mating hinge surface while painting inner and outer hinge pillar and door surfaces at the mounting zone. The service replacement hinges should be installed through the scribe marks after position into the body pillar or door while using the bolts and tapping plate which come with the kit. First tighten bolts to 5 nm (44 lb in) preliminary torque strength. Check the door alignment before bolting it into the body since the door must not close completely until you verify the lock engagement with the striker before tightening it to 25 nm torque (18 lb ft). After sealer application to the hinges users should perform a paint job on the hinge assembly before installing the door onto the vehicle.
Lower Hinge, Passenger Side
15994458
Q: How to replace the front side door hinge pin and bushings on GMC Savana 1500?
A:
The first step to replace front side door hinge pins and bushings is extracting the retainer pieces from the hinge pins. Using locking pliers secure the lower hinge pin while delivering it out with a soft-faced hammer. The door needs temporary support through lower hinge installation of a bolt. After acquiring the upper hinge pin with locking pliers you should drive it out with a soft-faced hammer. The bolt should be removed from the lower hinge pin opening and you need help to lift off the door from the vehicle. Remove the upper hinge pin bushings from the door by using an appropriate tool while doing the same with the lower hinge pin bushings from the body. Insert the lower hinge pin bushings through the body using a suitable fitting tool and do the same for the upper hinge pin bushings on the door. Two persons should assist with door refitting to the vehicle and maintain temporary positioning with a lower hinge bolt. Drive the upper hinge pin into the upper hinge through the pointed end using a soft-faced hammer before extracting the temporary bolt from the lower hinge. Then drive the lower hinge pin into the lower hinge from below through the pointed end by using the soft-faced hammer. Affix the hinge pin retainers onto their corresponding hinge pins.