How to replace the front brake line on Chevrolet Silverado 1500?

Before you replace the front brake hose, you will need to raise and support the vehicle, then you remove the tire and wheel assembly. Clean all dirt from brake hose and brake pipe fittings to install rubber cap, while plugging the open end of the brake pipe fitting to avoid fluid leakage and contamination. Make use of a back up wrench on the hose fitting where the brake pipe fitting is disconnected from the brake hose, and cap the fitting end. Unclipping the brake hose retaining clip from the hose mounting bracket, followed by brake hose bolt and bracket from the upper Control Arm, and Steering Knuckle. Lastly, disconnect the brake hose to caliper bolt from the brake caliper and pull out the brake hose and dispose of the 2 copper brake hose gaskets. For the installation, you should install 2 new copper brake hose gaskets and brake hose bolt to poor brake hose plus install brake hose to caliper bolt and 2-new washers on brake caliper, then tighten up bolt bolto 40 nm (30 ft. Lbs.). Make sure the hose is not twisted or touches any of the suspension components and install the brake hose into the bracket with the vehicle weight on the suspension. Reinstall and tighten the brake hose bolt and bracket to the Steering Knuckle and upper Control Arm with 9 nm (80 inch lbs.) and then reinstall the brake hose retaining clip. Remove the rubber cap or plug from the exposed brake pip fitting end and thread nut the brake pipe fitting nut to the brake hose stopping off as not to bend the bracket or pipe, then tighten the bolt to 25 nm (18 ft. Lbs.). Lastly, bleed the haridic brake system, reassemble the tire and wheel assembly, verify that the hose does not abuts any suspension or wheel pieces in radical rotations, and lower the vehicle.

How to Service and Repair Brake Lines Using the J 45405 Pipe Flaring Tool Kit on Chevrolet Silverado 1500?

To service and repair the brake pipes; use the J 45405 Pipe Flaring Tool Kit (J 45405) and make sure to use double-walled steel brake pipe to escape brake system failure. Start with the inspection of the area of the brake pipe to be replaced and its release from retainers if necessary. If the brake pipe needs to be sectioned, choose the desired random location away from bent or mounting points, measure the length of the pipe to be replaced, and add the flares required on pipe diameter. 6.35 mm (0.250 in) for 4.76 mm (3/16 in), 9.50 mm (0.374 in) for 6.35 mm (1/4 in), and 12.67 mm (0.499 in) respectively for 7.94 mm (5/16 in). Use the pipe cutter provided in the J 45405 (J 45405) to cut the brake pipe squarely and decide on the right size of brake pipe and tube nuts. If necessary, remove the nylon coating from the end of the brake pipe with the coating stripping tool supplied within the J 45405 (J 45405), with the provision of ensuring that the right blade size is used. De-bur the inside and outside diameter of the pipe with the de-burring tool that is included with the J 45405 (J 45405), then install the tube nuts and de-bur with any contaminants from the brake pipe and the J 45405 (J 45405). Turn the die clamping screw of the new J 45405 (J 45405) counter-clockwise, choose the die set corresponding to it, and install the die halves into the die cage. Place the prepared end of the pipe to be flared into the back of the dies and be sure that it fits correctly; after that, activate the lever for the J 45405 (J 45405) and create the flare. Inspect the flare and ensure that it has the right shape and diameter. 6.74-7.10mm (0.265-0.279in) for 4.76mm (3/16in), 8.57-9.27mm (0.344-0.358 in) for 6.35mm (1/4in) and 10.42-10.79mm (0.410-0.425 in) for 7.94mm (5/16in). Form the new pipe with a proper brake pipe bending tool if needed; keep a clearance of 19 mm (3/4 in) from all moving parts when installing and fixing the brake pipe to the retainers. Finally, bleed the hydraulic brake system and check out brake pipe flares for leaks with the engine running and brakes applied.

OEM Chevrolet Silverado 1500 Brake Line

Brake Hose

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

35 Brake Lines found

View related parts
Chevrolet Silverado 1500 Brake Line Part Number: 88983905
$68.67 MSRP: $134.44
You Save: $65.77 (49%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Pipe, Brake; Hydraulic Hose; Brake Hose; Pipe, Hydraulic Brake Pipe; Pipe, Hydraulic Brake
- Replaces: 25837622, 25837624, 84330459, 22726507, 84380488, 84330461
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2010-2013 Chevrolet Silverado 1500 | Hybrid, LS, LT, LTZ, WT, XFE | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L FLEX, 8 Cyl 5.3 L FLEX, 8 Cyl 6.0 L FULL HYBRID EV-FLEX (FHEV), 8 Cyl 6.2 L FLEX
View related parts
Chevrolet Silverado 1500 Flex Hose, Rear Passenger Side Part Number: 19366701
$47.49 MSRP: $92.18
You Save: $44.69 (49%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose Assembly, Rear Brake; Hydraulic Hose; Brake Hose; Brake Line; Hose, Hydraulic Brake
- Position: Rear Passenger Side
- Replaces: 15075747, 15102334, 15884694, 15748047, 21999529, 22163614
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1999-2007 Chevrolet Silverado 1500 | Base, Hybrid, LS, LT, LTZ, SS, WT, Z71 Off-Road | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
View related parts
Chevrolet Silverado 1500 Flex Hose, Front Passenger Side Part Number: 19366694
$58.21 MSRP: $112.98
You Save: $54.77 (49%)
ADD TO CART
Product Specifications
- Other Name: Hose Assembly, Front Brake; Hydraulic Hose; Brake Hose; Brake Line; Hose, Hydraulic Brake
- Position: Front Passenger Side
- Replaced by: 19435350
- Replaces: 15102331, 15196559, 15748042, 19331536, 22163524, 22163802, 15075742, 15882778, 21999052, 21999056
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1999-2007 Chevrolet Silverado 1500 | Base, Hybrid, LS, LT, LTZ, SS, WT, Z71 Off-Road | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
View related parts
Chevrolet Silverado 1500 Flex Hose, Rear Part Number: 19366712
$40.86 MSRP: $76.74
You Save: $35.88 (47%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose Assembly, Rear Brake; Hydraulic Hose; Brake Hose; Brake Line; Hose, Hydraulic Brake
- Position: Rear
- Replaced by: 19540529
- Replaces: 15195782, 15195571, 15884695, 21999531, 22163618
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1999-2007 Chevrolet Silverado 1500 | Base, Hybrid, LS, LT, LTZ, SS, WT, Z71 Off-Road | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
View related parts
Chevrolet Silverado 1500 Flex Hose, Rear Driver Side Part Number: 19366700
$48.39 MSRP: $90.88
You Save: $42.49 (47%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose Assembly, Rear Brake; Hydraulic Hose; Brake Hose; Brake Line; Hose, Hydraulic Brake
- Position: Rear Driver Side
- Replaced by: 19540524
- Replaces: 15102333, 15075746, 15748046, 21999528, 22163613, 15884702
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1999-2007 Chevrolet Silverado 1500 | Base, Hybrid, LS, LT, LTZ, SS, WT, Z71 Off-Road | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
View related parts
Chevrolet Silverado 1500 Flex Hose, Passenger Side Part Number: 84183650
$21.97 MSRP: $41.23
You Save: $19.26 (47%)
ADD TO CART
Product Specifications
- Other Name: Hose, Hydraulic Brake; Hydraulic Hose; Brake Hose; Brake Line
- Position: Passenger Side
- Replaces: 22846799
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2014-2019 Chevrolet Silverado 1500 | Custom, Custom Trail Boss, High Country, LS, LT, LT Trail Boss, LTZ, RST, SSV, WT | 6 Cyl 4.3 L FLEX, 6 Cyl 4.3 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.3 L MILD HYBRID EV-GAS (MHEV), 8 Cyl 6.2 L GAS
View related parts
Chevrolet Silverado 1500 Flex Hose, Driver Side Part Number: 84183649
$21.93 MSRP: $41.14
You Save: $19.21 (47%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose, Hydraulic Brake; Hydraulic Hose; Brake Hose; Brake Line
- Position: Driver Side
- Replaces: 22846798
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2014-2019 Chevrolet Silverado 1500 | Custom, Custom Trail Boss, High Country, LS, LT, LT Trail Boss, LTZ, RST, SSV, WT | 6 Cyl 4.3 L FLEX, 6 Cyl 4.3 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.3 L MILD HYBRID EV-GAS (MHEV), 8 Cyl 6.2 L GAS
View related parts
Chevrolet Silverado 1500 Flex Hose, Rear Driver Side Part Number: 19366704
$37.36 MSRP: $70.15
You Save: $32.79 (47%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose Assembly, Rear Brake; Hydraulic Hose; Brake Hose; Brake Line; Hose, Hydraulic Brake
- Position: Rear Driver Side
- Replaced by: 19540527
- Replaces: 15102353, 15884703, 21999533, 22163785, 19331533, 15749470
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2000-2006 Chevrolet Silverado 1500 | Base, Hybrid, LS, LT, SS, WT, Z71 Off-Road | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
View related parts
Chevrolet Silverado 1500 Flex Hose, Rear Part Number: 19366703
$42.01 MSRP: $76.03
You Save: $34.02 (45%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose Assembly, Rear Brake; Hydraulic Hose; Brake Hose; Brake Line; Hose, Hydraulic Brake
- Position: Rear
- Replaced by: 19540526
- Replaces: 21999534, 15749471, 15884704, 22163786, 19331534, 15102354
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2000-2006 Chevrolet Silverado 1500 | Base, Hybrid, LS, LT, SS, WT, Z71 Off-Road | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
View related parts
Chevrolet Silverado 1500 Flex Hose, Front Driver Side Part Number: 19366683
$36.06 MSRP: $111.76
You Save: $75.70 (68%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose Assembly, Front Brake; Hydraulic Hose; Brake Hose; Brake Line; Hose, Hydraulic Brake
- Position: Front Driver Side
- Replaced by: 19540521
- Replaces: 15101916, 15749763, 15749765, 22163531, 21999053, 22163873, 22163877, 15167035, 15852641
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2001-2007 Chevrolet Silverado 1500 | Base, Hybrid, LS, LT, LTZ, SS, WT, Z71 Off-Road | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
View related parts
Chevrolet Silverado 1500 Flex Hose, Front Passenger Side Part Number: 84331228
$21.63 MSRP: $40.61
You Save: $18.98 (47%)
ADD TO CART
Product Specifications
- Other Name: Hose Assembly-Front Brake; Hydraulic Hose; Brake Hose; Brake Line; Hose, Hydraulic Brake
- Position: Front Passenger Side
- Replaces: 15875928, 84183672, 15923784, 22829661, 23245429, 22946996, 25890939
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2007-2019 Chevrolet Silverado 1500 | Custom, Custom Trail Boss, High Country, Hybrid, LS, LT, LT Trail Boss, LTZ, RST, SSV, WT, XFE | 6 Cyl 4.3 L FLEX, 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L FLEX, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.3 L MILD HYBRID EV-GAS (MHEV), 8 Cyl 6.0 L FULL HYBRID EV-FLEX (FHEV), 8 Cyl 6.0 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 6.0 L GAS, 8 Cyl 6.2 L FLEX, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Silverado 1500 Flex Hose, Rear Passenger Side Part Number: 19366697
$33.21 MSRP: $100.82
You Save: $67.61 (68%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose Assembly, Rear Brake; Hydraulic Hose; Brake Hose; Brake Line; Hose, Hydraulic Brake
- Position: Rear Passenger Side
- Replaces: 15884693, 22163616, 15749768, 15102356, 15125376
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2006 Chevrolet Silverado 1500 | Hybrid, LS, LT, SS, WT | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
View related parts
Chevrolet Silverado 1500 Brake Hose, Front Driver Side Part Number: 87859245
$26.58 MSRP: $48.10
You Save: $21.52 (45%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose Assembly-Front Brake; Hose, Hydraulic Brake
- Position: Front Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2023 Chevrolet Silverado 1500 | PPV | 8 Cyl 5.3 L GAS
View related parts
Chevrolet Silverado 1500 Brake Hose, Front Driver Side Part Number: 86803653
$34.58 MSRP: $62.58
You Save: $28.00 (45%)
ADD TO CART
Product Specifications
- Other Name: Hose Assembly-Front Brake; Hose, Hydraulic Brake
- Position: Front Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2022-2023 Chevrolet Silverado 1500 | Custom, Custom Trail Boss, High Country, LT, LT Trail Boss, LTZ, PPV, RST, WT, ZR2 | 4 Cyl 2.7 L GAS, 6 Cyl 3.0 L DIESEL, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Silverado 1500 Flex Hose, Front Passenger Side Part Number: 84956403
$29.40 MSRP: $55.22
You Save: $25.82 (47%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose Assembly-Front Brake; Hydraulic Hose; Brake Hose; Brake Line; Hose, Hydraulic Brake
- Position: Front Passenger Side
- Replaces: 84956398, 84612461, 23363941, 84637393
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2019-2023 Chevrolet Silverado 1500 | Custom, Custom Trail Boss, High Country, LT, LT Trail Boss, LTZ, PPV, RST, SSV, WT, ZR2 | 4 Cyl 2.7 L GAS, 6 Cyl 3.0 L DIESEL, 6 Cyl 4.3 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Silverado 1500 Flex Hose, Front Driver Side Part Number: 84956401
$21.53 MSRP: $40.46
You Save: $18.93 (47%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose Assembly-Front Brake; Hydraulic Hose; Brake Hose; Brake Line; Hose, Hydraulic Brake
- Position: Front Driver Side
- Replaces: 84456359, 84956397, 84612460, 84829327, 84637394, 84613959
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2019-2023 Chevrolet Silverado 1500 | Custom, Custom Trail Boss, High Country, LT, LT Trail Boss, LTZ, PPV, RST, SSV, WT, ZR2 | 4 Cyl 2.7 L GAS, 6 Cyl 3.0 L DIESEL, 6 Cyl 4.3 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Silverado 1500 Brake Hose, Front Passenger Side Part Number: 87859246
$23.26 MSRP: $42.10
You Save: $18.84 (45%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose Assembly-Front Brake; Hose, Hydraulic Brake
- Position: Front Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2023 Chevrolet Silverado 1500 | PPV | 8 Cyl 5.3 L GAS
View related parts
Chevrolet Silverado 1500 Flex Hose, Front Driver Side Part Number: 84331227
$21.20 MSRP: $39.81
You Save: $18.61 (47%)
ADD TO CART
Product Specifications
- Other Name: Hose Assembly-Front Brake; Hydraulic Hose; Brake Hose; Brake Line; Hose, Hydraulic Brake
- Position: Front Driver Side
- Replaces: 15923783, 22946995, 22829660, 23245428, 25890938, 15875927, 84183671
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2007-2019 Chevrolet Silverado 1500 | Custom, Custom Trail Boss, High Country, Hybrid, LS, LT, LT Trail Boss, LTZ, RST, SSV, WT, XFE | 6 Cyl 4.3 L FLEX, 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L FLEX, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.3 L MILD HYBRID EV-GAS (MHEV), 8 Cyl 6.0 L FULL HYBRID EV-FLEX (FHEV), 8 Cyl 6.0 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 6.0 L GAS, 8 Cyl 6.2 L FLEX, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Silverado 1500 Flex Hose Part Number: 84183651
$24.46 MSRP: $44.27
You Save: $19.81 (45%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hose, Hydraulic Brake
- Replaces: 22847490
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2014-2018 Chevrolet Silverado 1500 | Custom, High Country, LS, LT, LTZ, SSV, WT | 6 Cyl 4.3 L FLEX, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.3 L MILD HYBRID EV-GAS (MHEV), 8 Cyl 6.2 L GAS
View related parts
Chevrolet Silverado 1500 Flex Hose, Passenger Side Part Number: 84697256
$17.42 MSRP: $32.71
You Save: $15.29 (47%)
ADD TO CART
Product Specifications
- Other Name: Hose, Hydraulic Brake; Hydraulic Hose; Brake Hose; Brake Line
- Position: Passenger Side
- Replaces: 23390430
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2019-2023 Chevrolet Silverado 1500 | Custom, Custom Trail Boss, High Country, LT, LT Trail Boss, LTZ, PPV, RST, SSV, WT, ZR2 | 4 Cyl 2.7 L GAS, 6 Cyl 3.0 L DIESEL, 6 Cyl 4.3 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L GAS

| Page 1 of 2 |Next >

1-20 of 35 Results

Chevrolet Silverado 1500 Brake Line

Want to cut long-term maintenance and repair costs? Choose OEM Brake Line. Those parts deliver top durability you can trust. On our site, you'll find a huge catalog of genuine Chevrolet Silverado 1500 parts. Prices are unbeatable, so you can keep more in your pocket. Every OEM Chevrolet Silverado 1500 Brake Line includes a manufacturer's warranty. You can also get an easy return policy that keeps buying risk free. Fast delivery, get your car on the road quickly. It's simple to search, compare, and order. Stop guessing about quality or fit. Order today and save with parts that last.

Chevrolet Silverado 1500 Brake Line Parts and Q&A

Flex Hose, Front Driver Side
19366683
Q: How to replace the front brake line on Chevrolet Silverado 1500?
A:
Before you replace the front brake hose, you will need to raise and support the vehicle, then you remove the tire and wheel assembly. Clean all dirt from brake hose and brake pipe fittings to install rubber cap, while plugging the open end of the brake pipe fitting to avoid fluid leakage and contamination. Make use of a back up wrench on the hose fitting where the brake pipe fitting is disconnected from the brake hose, and cap the fitting end. Unclipping the brake hose retaining clip from the hose mounting bracket, followed by brake hose bolt and bracket from the upper Control Arm, and Steering Knuckle. Lastly, disconnect the brake hose to caliper bolt from the brake caliper and pull out the brake hose and dispose of the 2 copper brake hose gaskets. For the installation, you should install 2 new copper brake hose gaskets and brake hose bolt to poor brake hose plus install brake hose to caliper bolt and 2-new washers on brake caliper, then tighten up bolt bolto 40 nm (30 ft. Lbs.). Make sure the hose is not twisted or touches any of the suspension components and install the brake hose into the bracket with the vehicle weight on the suspension. Reinstall and tighten the brake hose bolt and bracket to the Steering Knuckle and upper Control Arm with 9 nm (80 inch lbs.) and then reinstall the brake hose retaining clip. Remove the rubber cap or plug from the exposed brake pip fitting end and thread nut the brake pipe fitting nut to the brake hose stopping off as not to bend the bracket or pipe, then tighten the bolt to 25 nm (18 ft. Lbs.). Lastly, bleed the haridic brake system, reassemble the tire and wheel assembly, verify that the hose does not abuts any suspension or wheel pieces in radical rotations, and lower the vehicle.
Flex Hose, Front Passenger Side
84331228
Q: How to Service and Repair Brake Lines Using the J 45405 Pipe Flaring Tool Kit on Chevrolet Silverado 1500?
A:
To service and repair the brake pipes; use the J 45405 Pipe Flaring Tool Kit (J 45405) and make sure to use double-walled steel brake pipe to escape brake system failure. Start with the inspection of the area of the brake pipe to be replaced and its release from retainers if necessary. If the brake pipe needs to be sectioned, choose the desired random location away from bent or mounting points, measure the length of the pipe to be replaced, and add the flares required on pipe diameter. 6.35 mm (0.250 in) for 4.76 mm (3/16 in), 9.50 mm (0.374 in) for 6.35 mm (1/4 in), and 12.67 mm (0.499 in) respectively for 7.94 mm (5/16 in). Use the pipe cutter provided in the J 45405 (J 45405) to cut the brake pipe squarely and decide on the right size of brake pipe and tube nuts. If necessary, remove the nylon coating from the end of the brake pipe with the coating stripping tool supplied within the J 45405 (J 45405), with the provision of ensuring that the right blade size is used. De-bur the inside and outside diameter of the pipe with the de-burring tool that is included with the J 45405 (J 45405), then install the tube nuts and de-bur with any contaminants from the brake pipe and the J 45405 (J 45405). Turn the die clamping screw of the new J 45405 (J 45405) counter-clockwise, choose the die set corresponding to it, and install the die halves into the die cage. Place the prepared end of the pipe to be flared into the back of the dies and be sure that it fits correctly; after that, activate the lever for the J 45405 (J 45405) and create the flare. Inspect the flare and ensure that it has the right shape and diameter. 6.74-7.10mm (0.265-0.279in) for 4.76mm (3/16in), 8.57-9.27mm (0.344-0.358 in) for 6.35mm (1/4in) and 10.42-10.79mm (0.410-0.425 in) for 7.94mm (5/16in). Form the new pipe with a proper brake pipe bending tool if needed; keep a clearance of 19 mm (3/4 in) from all moving parts when installing and fixing the brake pipe to the retainers. Finally, bleed the hydraulic brake system and check out brake pipe flares for leaks with the engine running and brakes applied.