How to replace the front side door hinge on Chevrolet Lumina?

The initial step to replace the front side door hinge starts by opening the door and eliminating the rubber conduit. Apply grease pencil marks on both the door and body where the hinge will sit before using door support. Extract the door hinge to door bolts before pulling out the door hinge completely from the vehicle. The new door hinge must be put onto the vehicle before you install the door hinge to body bolts while keeping them finger-tight. After installation of the door hinge to door bolts begins the process of bolt finger tightening. Use the grease pencil marks to position the hinge correctly before tightening the door hinge to body bolts to 33 N.m (24 lb ft) and the door hinge to door bolts to the same torque value. Wash all remaining grease pencil residue from installation before putting back the rubber conduit. Finishing the process involves proper adjustment of the door.

How to replace the rear side door hinge on Chevrolet Lumina?

You should start with door opening followed by rubber conduit removal to access the rear side door hinge. Apply a grease pencil mark on the body and the door where the hinge will go before supporting the door. First remove the hinge bolts from the body before advancing to the bolt removal from the door. After that, pull the hinge out of the vehicle. Begin installing the new door hinge on the vehicle before fixing it to the body bolts while maintaining light torque. After installing the hinge to door bolts tighten them only by hand. Observed grease pencil marks on the hinge should guide its position to achieve accurate alignment. Begin by tightening the door hinge to body bolts to 33 N.m (24 lb ft) followed by a torque specification of the same value when securing the hinge to door bolts. Remove all extra marks from the rubber conduit and replace it back onto the vehicle body. Property adjustment steps should be performed at the end of this process.

OEM Chevrolet Lumina Door Hinge

Interior Door Hinge

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

15 Door Hinges found

View related parts
Chevrolet Lumina Hinge Assembly, Front Upper Passenger Side Part Number: 10218445
$57.04 MSRP: $110.64
You Save: $53.60 (49%)
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Front Door Upper Hinge; Door Hinge; Lower Hinge; Upper Hinge; Hinge; Hinge Kit, Front Door Lower Hinge
- Position: Front Upper Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1990-1994 Chevrolet Lumina | Base, Euro, Z34 | 4 Cyl 2.2 L GAS, 4 Cyl 2.5 L GAS, 6 Cyl 3.1 L FLEX, 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS
View related parts
Chevrolet Lumina Upper Hinge, Rear Driver Side Part Number: 10428296
$3.42 MSRP: $64.07
You Save: $60.65 (95%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge, Rear Side Door Upper Hinge; Door Hinge
- Position: Rear Upper Driver Side
- Replaces: 16632669, 10257212, 10169539, 16634681
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-2001 Chevrolet Lumina | Base, LS, LTZ | 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chevrolet Lumina Lower Hinge, Front Driver Side Part Number: 10428294
$64.13 MSRP: $85.33
You Save: $21.20 (25%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Assembly-Front Side Door Lower; Door Hinge; Hinge, Front Door Lower Hinge
- Position: Front Lower Driver Side
- Replaces: 10414647, 16632667, 16631243, 10257210, 16633097
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-2001 Chevrolet Lumina | Base, LS, LTZ | 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chevrolet Lumina Lower Hinge, Rear Driver Side Part Number: 10169531
$14.45 MSRP: $28.02
You Save: $13.57 (49%)
ADD TO CART
Product Specifications
- Other Name: Hinge, Rear Side Door Lower Hinge; Door Hinge
- Position: Rear Lower Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-2001 Chevrolet Lumina | Base, LS, LTZ | 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chevrolet Lumina Lower Hinge, Rear Passenger Side Part Number: 10169530
$6.36 MSRP: $31.32
You Save: $24.96 (80%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge, Rear Side Door Lower Hinge; Door Hinge
- Position: Rear Lower Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-2001 Chevrolet Lumina | Base, LS, LTZ | 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chevrolet Lumina Hinge Assembly, Rear Passenger Side Part Number: 12529216
Product Specifications
- Other Name: Hinge Kit, Rear Compartment Lid And End Gate; Door Hinge; Hinge
- Position: Rear Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-2001 Chevrolet Lumina | Base, LS, LTZ | 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chevrolet Lumina Upper Hinge, Rear Passenger Side Part Number: 10428295
Product Specifications
- Other Name: Hinge, Rear Side Door Upper Hinge; Door Hinge
- Position: Rear Upper Passenger Side
- Replaces: 16634680, 10169538, 10257211, 16632668
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-2001 Chevrolet Lumina | Base, LS, LTZ | 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chevrolet Lumina Lower Hinge, Front Passenger Side Part Number: 10428293
Product Specifications
- Other Name: Hinge Assembly-Front Side Door Lower; Door Hinge; Hinge, Front Door Lower Hinge
- Position: Front Lower Passenger Side
- Replaces: 16633096, 10257209, 10414646, 16631242
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1997-2001 Chevrolet Lumina | Base, LS, LTZ | 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chevrolet Lumina Hinge Assembly, Front Upper Driver Side Part Number: 10218446
Product Specifications
- Other Name: Hinge Kit, Front Door Upper Hinge; Door Hinge; Lower Hinge; Upper Hinge; Hinge; Hinge Kit, Front Door Lower Hinge
- Position: Front Upper Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1990-1994 Chevrolet Lumina | Base, Euro, Z34 | 4 Cyl 2.2 L GAS, 4 Cyl 2.5 L GAS, 6 Cyl 3.1 L FLEX, 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS
View related parts
Chevrolet Lumina Lower Hinge, Front Passenger Side Part Number: 16632666
Product Specifications
- Other Name: Hinge Assembly-Front Side Door Lower; Door Hinge; Hinge, Front Door Lower Hinge
- Position: Front Lower Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-1996 Chevrolet Lumina | Base, LS | 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS
View related parts
Chevrolet Lumina Hinge Assembly, Rear Driver Side Part Number: 10275697
Product Specifications
- Other Name: Hinge Kit, Rear Compartment Lid And End Gate; Door Hinge; Hinge
- Position: Rear Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-2001 Chevrolet Lumina | Base, LS, LTZ | 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chevrolet Lumina Hinge Assembly, Rear Upper Driver Side Part Number: 10218448
Product Specifications
- Other Name: Hinge Kit, Rear Side Door Upper Hinge; Door Hinge; Lower Hinge; Upper Hinge; Hinge
- Position: Rear Upper Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1990-1994 Chevrolet Lumina | Base, Euro | 4 Cyl 2.2 L GAS, 4 Cyl 2.5 L GAS, 6 Cyl 3.1 L FLEX, 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS
View related parts
Chevrolet Lumina Hinge Assembly, Rear Upper Passenger Side Part Number: 10218447
Product Specifications
- Other Name: Hinge Kit, Rear Side Door Upper Hinge; Door Hinge; Lower Hinge; Upper Hinge; Hinge
- Position: Rear Upper Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1990-1994 Chevrolet Lumina | Base, Euro | 4 Cyl 2.2 L GAS, 4 Cyl 2.5 L GAS, 6 Cyl 3.1 L FLEX, 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS
View related parts
Chevrolet Lumina Upper Hinge, Front Driver Side Part Number: 10167863
Product Specifications
- Other Name: Hinge Assembly-Front Side Door Upper; Door Hinge; Hinge, Front Door Upper Hinge
- Position: Front Upper Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-2001 Chevrolet Lumina | Base, LS, LTZ | 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS, 6 Cyl 3.8 L GAS
View related parts
Chevrolet Lumina Upper Hinge, Front Passenger Side Part Number: 10167862
Product Specifications
- Other Name: Hinge Assembly-Front Side Door Upper; Door Hinge; Hinge, Front Door Upper Hinge
- Position: Front Upper Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-2001 Chevrolet Lumina | Base, LS, LTZ | 6 Cyl 3.1 L GAS, 6 Cyl 3.4 L GAS, 6 Cyl 3.8 L GAS

Chevrolet Lumina Door Hinge

Want to cut long-term maintenance and repair costs? Choose OEM Door Hinge. Those parts deliver top durability you can trust. On our site, you'll find a huge catalog of genuine Chevrolet Lumina parts. Prices are unbeatable, so you can keep more in your pocket. Every OEM Chevrolet Lumina Door Hinge includes a manufacturer's warranty. You can also get an easy return policy that keeps buying risk free. Fast delivery, get your car on the road quickly. It's simple to search, compare, and order. Stop guessing about quality or fit. Order today and save with parts that last.

Door Hinge is one of the remarkable parts that represent the line of cars with high reliability and performance characteristic at Chevrolet Lumina car model and series that was manufactured from 1989 to 2013. This Door Hinge has the primary responsibility of properly fixing the door onto the vehicle frame, while at the same time functioning effectively should the door need to be opened or closed. Eventually, doors also become loose and there is no assurance that they are properly aligned thus correct safety precautions are not met and efficiency decreases. Bolted and welded Door Hinges are stylish, and different Lumina models can use them, which is an advantage. There are replacement solutions: entire hinge assemblies made of sturdy steel, and kits with replacement for most worn parts, this way, Chevrolet Lumina remains the car of high performance. More importantly, today's Lumina models have door check straps, which help reduce door movement and thus increase safety. Besides, the Door Hinge is also part of the vehicle's framework and may also help in averting dangers to the passengers through guaranteeing that doors shut firmly. Comprehensively, in the Door Hinge, there exists high structural durability necessary in the automobile market and compatibility with differing generations of Lumina. Speaking of this component, one can mention the company's adherence to the policy of high quality; therefore, the Chevrolet Lumina is the automobile that can meet the expectations of those drivers who are looking for powerful cars with the maximum level of protection.

Chevrolet Lumina Door Hinge Parts and Q&A

Upper Hinge, Front Passenger Side
10167862
Q: How to replace the front side door hinge on Chevrolet Lumina?
A:
The initial step to replace the front side door hinge starts by opening the door and eliminating the rubber conduit. Apply grease pencil marks on both the door and body where the hinge will sit before using door support. Extract the door hinge to door bolts before pulling out the door hinge completely from the vehicle. The new door hinge must be put onto the vehicle before you install the door hinge to body bolts while keeping them finger-tight. After installation of the door hinge to door bolts begins the process of bolt finger tightening. Use the grease pencil marks to position the hinge correctly before tightening the door hinge to body bolts to 33 N.m (24 lb ft) and the door hinge to door bolts to the same torque value. Wash all remaining grease pencil residue from installation before putting back the rubber conduit. Finishing the process involves proper adjustment of the door.
Lower Hinge, Rear Driver Side
10169531
Q: How to replace the rear side door hinge on Chevrolet Lumina?
A:
You should start with door opening followed by rubber conduit removal to access the rear side door hinge. Apply a grease pencil mark on the body and the door where the hinge will go before supporting the door. First remove the hinge bolts from the body before advancing to the bolt removal from the door. After that, pull the hinge out of the vehicle. Begin installing the new door hinge on the vehicle before fixing it to the body bolts while maintaining light torque. After installing the hinge to door bolts tighten them only by hand. Observed grease pencil marks on the hinge should guide its position to achieve accurate alignment. Begin by tightening the door hinge to body bolts to 33 N.m (24 lb ft) followed by a torque specification of the same value when securing the hinge to door bolts. Remove all extra marks from the rubber conduit and replace it back onto the vehicle body. Property adjustment steps should be performed at the end of this process.